Introduction

Before accessing the joystick, several prerequisite steps are required. This guide will show you how to disassemble to device in order to access the joystick for proper maintenance.

Begin the disassembly by placing your Sony Ericsson QuickShare T630 on a flat surface.
  • Begin the disassembly by placing your Sony Ericsson QuickShare T630 on a flat surface.

Ajouter un commentaire

Slide the protective panel on the backside of the phone downward and remove it entirely, revealing the battery underneath. Slide the protective panel on the backside of the phone downward and remove it entirely, revealing the battery underneath.
  • Slide the protective panel on the backside of the phone downward and remove it entirely, revealing the battery underneath.

Ajouter un commentaire

Slide the battery upward to remove.
  • Slide the battery upward to remove.

Ajouter un commentaire

Remove the rubber plug located near the camera by gently prying upward with your fingers. Gently lift the camera shield after removal of the rubber plug.
  • Remove the rubber plug located near the camera by gently prying upward with your fingers.

  • Gently lift the camera shield after removal of the rubber plug.

Ajouter un commentaire

Pry the remaining panel to loosen its contact to the phone using a spudger. Slide the panel upward to remove it completely.
  • Pry the remaining panel to loosen its contact to the phone using a spudger.

  • Slide the panel upward to remove it completely.

  • These steps will require a slight appliance of force.

Ajouter un commentaire

Slide the aerial upward to remove it.
  • Slide the aerial upward to remove it.

Ajouter un commentaire

Locate screws on four corners of device Remove the screws
  • Locate screws on four corners of device

  • Remove the screws

Ajouter un commentaire

Gently lift and remove the front panel of the phone after removing the screws. Gently lift and remove the front panel of the phone after removing the screws.
  • Gently lift and remove the front panel of the phone after removing the screws.

Ajouter un commentaire

This step is NOT required for joystick maintenance or keypad maintenance and replacement! Continue on to step 10 if you are attempting to achieve either of these goals. Slowly lift the screen to reveal the green circuit ribbon connecting the screen to the phone. Gently pull the ribbon from the circuit/
  • This step is NOT required for joystick maintenance or keypad maintenance and replacement! Continue on to step 10 if you are attempting to achieve either of these goals.

  • Slowly lift the screen to reveal the green circuit ribbon connecting the screen to the phone.

  • Gently pull the ribbon from the circuit/

  • Remove the now disconnected screen.

Ajouter un commentaire

Remove the keyboard by slowly pulling it away from the circuit board. There are no direct connections between the keyboard and phone. These are all of the parts covered in this disassembly that make up the Sony Ericsson QuickShare T630.
  • Remove the keyboard by slowly pulling it away from the circuit board.

    • There are no direct connections between the keyboard and phone.

    • These are all of the parts covered in this disassembly that make up the Sony Ericsson QuickShare T630.

Ajouter un commentaire

Gently lift the white circuit board to reveal the base.
  • Gently lift the white circuit board to reveal the base.

Ajouter un commentaire

Soak cotton swab in rubbing alcohol
  • Soak cotton swab in rubbing alcohol

  • Gently work the cotton swab around the joystick, removing any waste buildup that may hinder its use.

Ajouter un commentaire

Conclusion

To reassemble your device, follow these instructions in reverse order.

Shelby Hartin

Membre depuis le 28/10/2013

139 Réputation

1 tutoriel rédigé

Équipe

University of Maine, Team 1-1, Diaz Fall 2013 Membre de l'équipe University of Maine, Team 1-1, Diaz Fall 2013

UMAINE-DIAZ-F13S1G1

4 membres

3 tutoriels rédigés

Ajouter un commentaire

Voir les statistiques:

Dernières 24 heures : 0

7 derniers jours : 0

30 derniers jours : 8

Total : 752