Introduction

This repair guide will guide you through the steps to removing and replacing the power switch of your APS Tech 101629 CD-Drive.

First the external casing, and channel switch will need to be removed.

Pry 4 plastic feet off the bottom of the enclosure using the iPod opening tool.
  • Pry 4 plastic feet off the bottom of the enclosure using the iPod opening tool.

Ajouter un commentaire

Unscrew the four screws previously covered by the feet.
  • Unscrew the four screws previously covered by the feet.

Ajouter un commentaire

  • Flip the device right side up, then gently slide the casing upwards and off the hard drive.

Ajouter un commentaire

  • Flip device upside down again.

  • Gently pry the bottom gray casing away from the device.

Ajouter un commentaire

  • Rotate so back of device is facing you, then gently pry the back casing away.

  • When back casing is removed, the fan will become loose.

Ajouter un commentaire

  • Disconnect ID cable.

  • Make sure to lift the white portion of the connection first, as this holds the two connectors together.

Ajouter un commentaire

  • For easier access the fan is loose and can be easily moved but not disconnected.

  • Using spudger, depress pressure holders at all 4 corners.

  • Pull out, removing cord as well.

Ajouter un commentaire

  • Depress 2 pressure holds on each side of the power switch.

  • Press out the back of the device.

Ajouter un commentaire

  • Remove all four 4 connections from the power switch.

    • Remember that the straight connections are on the far side, while the L-shaped connections are on the near side, and that both yellow connections are on top. This is helpful for reassembly.

  • These are very hard to get off, use patience and wiggling.

Ajouter un commentaire

Conclusion

To reassemble your device, follow these instructions in reverse order.

Alexis Weckel

Membre depuis le 11/04/2011

140 Réputation

3 tutoriels rédigés

Équipe

Cal Poly, Team 24-60, Amido Spring 2011 Membre de l'équipe Cal Poly, Team 24-60, Amido Spring 2011

CPSU-AMIDO-S11S24G60

5 membres

6 tutoriels rédigés

Ajouter un commentaire

Voir les statistiques:

Dernières 24 heures : 0

7 derniers jours : 0

30 derniers jours : 0

Total : 459