Aller au contenu principal

Repairing Vehicle Headliner

Ce dont vous avez besoin

  1. Repairing Vehicle Headliner, Repairing Vehicle Headliner: étape 1, image 1 de 1
    • Prep the car for work.

    • Disconnect the negative battery terminal.

    • Removal of the right passenger seat may be necessary to help remove the headliner from the car.

    • Remove the trim.

    • Unbolt the sun visors, dome lamp, grab handles and any other accessories that are attached to the ceiling.

    • Remove the upper seat belt mounting loops.

    • Remove and/or pull back just enough of the side interior trim panels to gain access to the edge of the headliner. Complete removal of these panels is usually not needed.

    • Lower one side of the headliner panel and slide it over to clear the trim panels.

    • Turn the panel and remove it from the vehicle.

  2. Repairing Vehicle Headliner: étape 3, image 1 de 2 Repairing Vehicle Headliner: étape 3, image 2 de 2
    • Remove the old fabric from the board.

    • Place the headliner panel on a clean work table.

    • Carefully pull the old fabric material off the board. Usually the foam backing will remain stuck to the headliner board. Use a piece of the old material to rub the old foam loose from the board.

    • Vacuum the foam bits from the backing board.

  3. Repairing Vehicle Headliner: étape 4, image 1 de 3 Repairing Vehicle Headliner: étape 4, image 2 de 3 Repairing Vehicle Headliner: étape 4, image 3 de 3
    • Install new fabric:

    • If the board is damaged, repair it using aluminum tape. Any rough areas might show after the new fabric is applied.

    • Lay out the new fabric over the board. Pull 1/2 of it back over itself.

    • Spray headliner adhesive glue on 1/2 of the board and the back side of the fabric.

    • Carefully place the fabric onto the board starting from the center point and smooth it outward wit your hand as you lay it down.

    • Pull up the other 1/2of the fabric over the side you just glued down. Repeat the above steps to lay down this side of the fabric.

    great info ! can you tell me if the trim fix spray adhesive bonds strongly onto the alluminium tape repaired areas ? is there a good alluminium tape that you can recommend for this. many thanks…

    mike

    mike avery - Réponse

    A good name-brand spray adhesive will stick to the aluminum tape. I buy my aluminum tape at Home Depot in the HVAC section. https://www.homedepot.com/p/Nashua-Tape-...

    HemiBill - Réponse

  4. Repairing Vehicle Headliner: étape 5, image 1 de 3 Repairing Vehicle Headliner: étape 5, image 2 de 3 Repairing Vehicle Headliner: étape 5, image 3 de 3
    • Trim up the fabric edges

    • Fold over the front & rear edges and glue them to the back side of the board about 1 inch from the edge.

    • Cut the side edges flush with the board. Also cut any access holes for the sun visors and other accessories that were previously removed.

  5. Repairing Vehicle Headliner: étape 6, image 1 de 3 Repairing Vehicle Headliner: étape 6, image 2 de 3 Repairing Vehicle Headliner: étape 6, image 3 de 3
    • Reinstall the headliner to the car:

    • Reverse the removal steps to re-install the headliner into the car.

    • Start one edge over the side trim panels and then raise the headliner into position over the other side trim panels.

    • Re-install the sun visors, dome lamp, seat belt upper loops and any other items that were previously removed

    • Lightly brush the headliner to remove marks & fingerprints.

    • If any of the trim clips break off of the interior trim panels, you can reattach them to the panel with 2-part epoxy glue.

Conclusion

To reassemble your device, follow these instructions in reverse order.

16 autres ont terminé cette réparation.

HemiBill

Membre depuis le 05/30/12

3 092 Réputation

2 tutoriels rédigés

3 commentaires

Excellent directions. I'd like to see a well made video of the procedure! Thanks,

Dub

bullfeather - Réponse

Thank you so much. I've never tried anything like this before, you've made it seem like even I can do it. I'm excited to save a cpl hundred by doing it myself!

Patti L Walton - Réponse

I like the steps you laid out. Its a very easy job of you have patience. Its a virtue in itself. All headliners are made different and from different material. Thank you for sharing this,

Michael Smith - Réponse

Ajouter un commentaire

Nombre de vues :

Dernières 24 heures : 2

7 derniers jours : 25

30 derniers jours : 117

Total : 81,636